CHMNV - 615 FLUX
- MSDS: CHMNV
- Manufacturer: ALPHA METALS INC
- Product Name: 615 FLUX
- National Stock Number: 6850-00F040474
Product Identification
Product ID:615 FLUX
MSDS Date:02/23/1996
FSC:6850
NIIN:00F040474
MSDS Number: CHMNV
Responsible Party
JERSEY CITY, NJ 07304-1027
US
Emergency Phone: 201-434-7508
Info Phone: 201-434-7508
Cage: 96596
Contractor
Telephone: 201-434-6778
Cage: 96613
Ingredients
ROSIN ACID, YELLOW RESIN, ROSIN CORE SOLDER PYROLYSIS
CAS: 8050-09-7
RTECS: VL0480000
Fraction By Weight: 35%
ISOPROPANOL (ISOPROPYL ALCOHOL), 2-PROPANOL, DIMETHYL
CAS: 67-63-0
RTECS: NT8050000
Fraction By Weight: 25-50%
OSHA PEL 400 PPM
ACGIH TLV: 400 PPM
STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS
CAS: 8052-41-3
RTECS: WJ8925000
Fraction By Weight: 5-10%
OSHA PEL 500 PPM
ACGIH TLV: 100 PPM
Hazards
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE AN ALLERGIC
REACTION TO THROAT, RESPIRATORY IRRITATION & DAMAGE. ASPHYXIATION.
INGESTION: GI IRRITATION. ASPIRATION OF MATERIAL INTO THE LUNGS CAN
CAUSE CHEMICAL PNEUMONITIS WHIC H CAN BE FATAL. SKIN: MAY CAUSE
ALLERGIC REACTION & DERMATITIS. EYES: SEVERE IRRITATION. (SEE SUPP)
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, HEADACHE, IRRITATION,
UNCONSCIOUSNESS, NAUSEA, VOMITING, DIARRHEA, DEFATTING, TEARING,
BLURRED VISION.
Medical Cond Aggravated by Exposure:CHEMICAL HYPERSENSITIVITY &
DISEASES OF THE LUNGS.
First Aid
First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF NEEDED.
KEEP WARM & QUIET. INGESTION: DON'T INDUCE VOMITING, KEEP WARM &
QUIET. ASPIRATION HAZARD. SKIN: WASH W/SOAP & WATER. EYES: FLUSH
W/LARGE AM OUNTS OF WATER. OBTAIN MEDICAL ATTENTION IN ALL CASES.
NOTES TO PHYSICIAN: MINERAL SPIRITS IS AN ALIPHATIC PETROLEUM
HYDROCARBON. IN CASE OF INGESTION, GASTRIC LAVAGE IS RECOMMENDED.
Fire Fighting
Flash Point Method:TCC
Flash Point:53F
Lower Limits:1
Extinguishing Media:CO2/DRY CHEMICAL.
Fire Fighting Procedures:USE SCBA IN ENCLOSED AREA. COOL EXPOSED
CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND. NEVER USE WELDING TORCH ON/NEAR CONTAINERS(EVEN
EMPTY).
Accidental Release
Spill Release Procedures:KEEP AWAY FROM IGNITION SOURCES. VENTILATE IF
IN ENCLOSED AREA. ADD ABSORBENT & SCOOP INTO APPROPRIATE CONTAINER.
TRANSFER TO HOOD & EVAPORATE/SEAL FOR WASTE DISPOSAL.
Handling
Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AWAY FROM IGNITION SOURCES IN A COOL DRY AREA W/ADEQUATE
VENTILATION. READ ALL CONTAINER LABELING.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DON'T TAKE INTERNALLY.
FOR INDUSTRIAL USE ONLY. SINCE EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUES ALL LABELED HAZARD PRECAUTIONS.
Exposure Controls
Respiratory Protection:IF LIMIT IS EXCEEDED, THEN A NIOSH APPROVED
CARTRIDGE TYPE RESPIRATOR SHOULD BE WORN.
Ventilation:SUFFICIENT MECHANICAL(GENERAL/LOCAL EXHAUST) TO MAINTAIN
EXPOSURE LEVELS BELOW TLV'S.
Protective Gloves:RESISTANT/RUBBER/NEOPRENE/PLASTIC
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:EYE BATH STATION.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
HLTH HZRD CONT'D: OVEREXPOSURE TO ISOPROPYL ALCOHOL CAUSES KIDNEY
DAMAGE IN HUMANS.
Chemical Properties
Boiling Pt:B.P. Text:180F
Vapor Pres:33
Vapor Density:2.1
Spec Gravity:0.878
pH:5-6
Evaporation Rate & Reference:(BU AC = 1): 2.5
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR PALE YELLOW LIQUID W/NON-RESIDUAL ODOR
Percent Volatiles by Volume:63
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HEAT, SPARKS & OPEN FLAMES.
Hazardous Decomposition Products:THERMAL: CO, CO2, ABIETIC ACID,
ALIPHATIC ALDEHYDES, TERPENES & OTHER ACIDS.
Disposal
Waste Disposal Methods:DESTROY BY APPROVED INCINERATION/DEPOSIT IN
APPROVED LANDFILL, IAW/FEDERAL, STATE & LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.